Testing a Transformer- How To Accurately Test A Transformer

There is two types of transformers in the market- linear transformer and switch mode power transformer. The transformers design is different. Sometimes it is just referred as ac transformer. Linear transformer mostly used in radio, project kits, VCD and etc while switch mode transformer can be found in Monitor, Tv, Fax and so on.

A transformer consists of two or more coils wound on the same core. For power transformers, the core material is usually iron. For a radio-frequency transformer, the core material is usually ferrite or air. The basic property of a transformer is to change AC voltage. A transformer cannot change direct current voltage. A step down transformer has a lower AC output voltage at its secondary winding than the AC input voltage to its primary winding. Conversely, a step up transformer has a higher secondary than primary voltage. The transformer laminations or coating of shellac, enamel or varnish is to insulate adjacent turns from shorts between winding. I will not go too details about how transformer work and transformer calculation as you can read more details from most electrical and electronic transformers books.

How to test transformers: Transformer failures are relatively rare in most electronic equipment, compared with other components. If too much current goes through a coil or winding, the winding heats up and can either open up completely, or the insulation between turns of wire can break down, causing the coil to be partly or completely shorted.

Just like a coil, you can check continuity of any primary or secondary transformer winding. The actual value of DC resistance you read is rather meaningless, but at least you will know whether a winding is open. Checking linear transformer is quite straight forward. Apply the ac voltage to the primary winding and expect output voltage at the secondary side. No or low output voltage means the transformer winding has open or shorted winding. Look for any evidence of overheating, such as darkened or blackened areas or a burnt smell.

About how to test a power transformer-it is a little bit complicated. You cannot apply ac voltage to the equipment and expect the desire output at the secondary side without connect to load otherwise over voltage will happen (because you have removed all the secondary load) and will blow the power section which consist of power fet, pwm ic and etc. Swith mode power supply are designed to run with load while linear transformer can be test without load.

The best way to test a switch mode power transformer is first remove it from the board. Check only the primary winding as secondary winding failures are exceedingly rare. How do we know which one is the primary winding? Trace from the big filter cap the positive pin to see where the circuit goes. It will go to one of the pin of the transformer. Then look for the power fet middle pin which is the Drain and it will lead to another pin of the transformer. This two pins is the primary winding of the transformer. Checking the resistance of the primary winding only can reveal whether it is open but it cannot check if it has developed a shorted winding. Only by using a ringer test you will know if it shorted or not. A shorted turn in the primary winding can cause the power section to blow.

The cheapest ringer tester that i came across is Dick Smith LOPT METER or flyback tester. Just connect the probes to the primary winding and the result are instantly seen from the Led bar graph. 4-8 bar represent a good winding, 1-2 bar represent partial short and if the led goes off means there is a heavy short in the winding. Besides checking the transformer it can be use to check B+ COIL, horizontal yoke coil and flyback primary winding and ballast (choke).

The expensive ringer tester is from sencore equipment. Sencore LC102 and LC103C besides checking capacitor it also have the capability to check all kind of winding. Whether it is a low voltage transformer, high voltage transformer, current transformer, pulse transformer, electric transformer, custom transformer this equipment will be able to check and test it.

If you do not wish to invest on this tester you may use a light bulb to check it. Remove one of the primary winding pin and connect a 60 watt light bulb. One end to the circuit while the other to the transformer pin. If the bulb light and didn't goes off suspect a shorted winding and if the light goes off, the winding is ok.

Transformer repair is not easy and it require a good skill to do it. Most of the transformer repairer preferred to rewind bigger winding such as fan, car alternator and starter. Swith mode power transformer is a little bit difficult to rewind because of the small size and low price.

Jestine Yong is a electronic repairer and a writer. For more information about electronic repair please visit his website at http://www.noahtec.com/electronic-repai r-articles.htm

---

Flyback Transformer-How to Locate the ABL Line

Whenever there is a complaint about monitor contrast problem I... Read More

Survey of Both Past and Modern Printers

Printers are on-line devices initially categorised as being either impact... Read More

Wireless Networking, Part 2: Setup and Security

The first installment in this two-part series of Tech Tips... Read More

Hard Drive Selection

Perhaps the biggest mistake people make when building their computer(s)... Read More

Wireless Notebooks: What You Need To Know About Going Wireless!

It's not exactly breaking news that our world is becoming... Read More

How To Choose a Computer Mouse

Computer MiceEvery computer user can hopefully identify their mouse and... Read More

Looking for Information on CD Duplication and Replication?

Time is one of the most important things we have... Read More

Inkjet Jargon Explained

With all the technical terms out there, it is becoming... Read More

Laptop Notebook ? Inexpensive Business Laptops

Laptop Notebook ? Your Portable OfficeIn much of today's business... Read More

A Review of Refurbished HP Laptops

HP refurbished laptops can be found on their website hpshopping.com.... Read More

Your Hard Drive is Going to Explode ? Why a UPS is Essential

It's most peoples worst computing nightmare. You wake up in... Read More

To Upgrade or Not?

To upgrade or not? That is the question. At least,... Read More

Setting up a Tape Backup Strategy for your Business

So you know a little bit about tape backup, but... Read More

Purchasing Laser Toner Refills

Laser toner refills can be expensive. Over the life of... Read More

SED is Coming

One of the bigger challenges facing display manufacturers is to... Read More

Buying a New Computer

Someone recently asked me "I teach senior citizens in a... Read More

JunxionBox -- WiFi Access Everywhere

Now you can more easily access the Internet wherever mobile... Read More

Types Of Laptop Batteries

Throughout the years there have been many technologies involved with... Read More

Printer Ink Cartridges - The History

You are working at your computer and trying to print... Read More

The Constantly Changing World of Inkjet Technology

We have finally advanced to a time when technology can... Read More

Your Business versus Mother Nature

Business Consultants earn hundreds of thousands of dollars every year... Read More

Understanding Transistor Data and Replacement

If, for some reason, you can't get an exact replacement... Read More

Flash Memory Part 2: MMC and SD

MMC and SDFlash memory is available in so many formats... Read More

Pixel Disruption To Cause Nausea From User of Computer Screen

As we study the issues associated with teaching kids in... Read More

How To Choose The Best Gaming Laptop

The gaming laptop is coming of age! It is steadily... Read More